JR DESSERT BAKERY

NO EVIDENCE OF RODENT OR INSECT OUTER OPENINGS PROTECTED/RODENT PROOFED, A WRITTEN LOG SHALL BE MAINTAINED AVAILABLE TO THE INSPECTORS - Comments: THE REAR EXIT SCREEN DOOR IS NOT PROPERLY RODENT PROOFED. 1/4" GAP AT THE TOP OF THE DOOR, ACCESSIBLE FOR FLIES TO ENTER, DOOR WAS OPENED DURING INSPECTION. INSTRUCTED TO INSTALL PROPER THRESHOLD TO PREVENT THE ENTRY OF INSECTS AND MAINTAIN. ALSO, EXIT DOOR IN THE BOX ROOM NOT RODENT PROOFED. THRESHOLD IS INSTALLED, BUT 1/4" GAP IS STILL PRESENT AT BOTTOM OF THE DOOR. INSTRUCTED TO INSTALL PROPER THRESHOLD TO PREVENT RODENT ENTRY AND MAINTAIN. SERIOUS VIOLATION 7-38-020.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: BROKEN DOOR GASKET ON THE 2-DOOR COOLER ON THE WEST WALL IN THE TEMP ROOM. INSTRUCTED TO REPAIR AND MAINTAIN. ALSO, EXCESSIVE ICE ACCUMULATION IN THE WALK IN FREEZER IN THE BOX ROOM, INSTRUCTED TO DEFROST, CLEAN ND MAINTAIN.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: OBSERVED INTERIOR OF COOLERS NOT CLEAN IN PREP AREAS. INSTRUCTED TO CLEAN, SANITIZE AND MAINTAIN.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: OBSERVED A HOLE IN THE CEILING TILE IN THE REAR OF THE BAKING ROOM. HOOD AND FILTERS WITH DUST AND FOOD ACCUMULATION. INSTRUCTED TO REPAIR, CLEAN AND MAINTAIN.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: OBSERVED NON WORKING LIGHTS THROUGHOUT THE PREMISES, INSTRUCTED TO INSTALL WORKING LIGHTS AND MAINTAIN.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: OBSERVED CLUTTER IN THE BOX ROOM STORAGE AREA, INSTRUCTED TO CLEAN, ORGANIZE AND REMOVE ITEMS 6" OFF FLOORS TO PREVENT RODENT HARBORAGE AND MAINTAIN

SANITIZING RINSE FOR EQUIPMENT AND UTENSILS: CLEAN, PROPER TEMPERATURE, CONCENTRATION, EXPOSURE TIME - Comments: OBSERVED HT DISH MACHINE IN THE PREP AREA NOT REACHING A FINAL RINSE OF 180F, MACHINE ONLY REACHED 150F, WITNESSED BY BOTH MANGER AND SANITARIAN. PER OFFICE, 48 HRS. NOTICE WAS GIVEN TO REPAIR DISH MACHINE. REPAIRMAN HAS BEEN CONTACTED AND IN ROUTE. UNIT TAGGED. DISCONTINUE USE UNTIL MACHINE IS FIXED. WILL RETURN ON 6/22/2016 TO INSPECT MACHINE. CRITICAL VIOLATION 7-38-030

NO EVIDENCE OF RODENT OR INSECT OUTER OPENINGS PROTECTED/RODENT PROOFED, A WRITTEN LOG SHALL BE MAINTAINED AVAILABLE TO THE INSPECTORS - Comments: OBSERVED APPROXIMATELY 25 RODENT DROPPINGS IN A REAR CORNER ON THE SIDE OF THE TOILET ROOM IN THE PREP/MIXING ROOM AREA. INSTRUCTED TO REMOVE DROPPINGS, CLEAN AND SANITIZE AFFECTED AREA, AND CONTACT PEST CONTROL FOR SERVICE. ALSO, IN SAID ROOM, THE REAR EXIT SCREEN DOOR IS NOT PROPERLY RODENT PROOFED. 1/4" GAP AT THE TOP OF THE DOOR, ACCESSIBLE FOR FLIES TO ENTER, DOOR WAS OPENED DURING INSPECTION. INSTRUCTED TO INSTALL PROPER THRESHOLD TO PREVENT THE ENTRY OF INSECTS AND MAINTAIN. ALSO, EXIT DOOR IN THE BOX ROOM NOT RODENT PROOFED. THRESHOLD IS INSTALLED, BUT 1/4" GAP IS STILL PRESENT AT BOTTOM OF THE DOOR. INSTRUCTED TO INSTALL PROPER THRESHOLD TO PREVENT RODENT ENTRY AND MAINTAIN. SERIOUS VIOLATION 7-38-020.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: OBSERVED RAW WOOD IN THE WALK IN FREEZER IN THE GARAGE. INSTRUCTED TO SEAL WOOD. BROKEN DOOR GASKET ON THE 2-DOOR COOLER ON THE WEST WALL IN THE TEMP ROOM. INSTRUCTED TO REPAIR AND MAINTAIN. ALSO, EXCESSIVE ICE ACCUMULATION IN THE WALK IN FREEZER IN THE BOX ROOM, INSTRUCTED TO DEFROST, CLEAN ND MAINTAIN.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: OBSERVED INTERIOR OF COOLERS NOT CLEAN IN PREP AREAS. INSTRUCTED TO CLEAN, SANITIZE AND MAINTAIN.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: OBSERVED FLOORS NOT CLEAN IN THE FOLLOWING AREAS; PREP, TOILET ROOMS, AND BOX ROOM. ALSO, HOLES AT THE FLOOR BASE OF THE MENS ROOM INSTRUCTED TO CLEAN, REPAIR AND MAINTAIN.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: OBSERVED A HOLE IN THE CEILING TILE IN THE REAR OF THE BAKING ROOM. HOOD AND FILTERS WITH DUST AND FOOD ACCUMULATION. WALL BASE DETACHED IN THE TOILET ROOM LOCATED IN THE BOX ROOM. INSTRUCTED TO REPAIR, CLEAN AND MAINTAIN.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: OBSERVED NON WORKING LIGHTS THROUGHOUT THE PREMISES, INSTRUCTED TO INSTALL WORKING LIGHTS AND MAINTAIN.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: INSTALL SPLASH GUARD AT THE ONLY EXPOSED HAND SINK IN THE PREP AREA BETWEEN THE SINK AND PREP TABLE TO PREVENT CONTAMINATION AND MAINTAIN.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: OBSERVED CLUTTER IN THE BOX ROOM STORAGE AREA, INSTRUCTED TO CLEAN, ORGANIZE AND REMOVE ITEMS 6" OFF FLOORS TO PREVENT RODENT HARBORAGE AND MAINTAIN.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: Large mixer in food prep area had peeling paint, shall be repaired/sealed. Walk in freezer had raw wood shelving, shall be repaired/sealed or replaced. Cooler shelving/racks that had peeling paint/rust, shall be repaired/replaced.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: Walk in cooler shelving/racks not clean need detailed cleaning(crevices), prep tables lower shelving not clean, need detailed cleaning.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: Floors in rear storage areas that had broken, missing floor tiles, shall be replaced/repaired. Floors by hot water heater area, and rear storage area not clean, need detailed cleaning(corners).

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: Walls, ceilings that had peeling paint, raw wood in rear storage area, shall be repaired/sealed.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: Stock items must be stored six inches off of floor to prevent pest harborage.

FOOD HANDLER REQUIREMENTS MET - Comments: Must provide food handlers list for next routine inspection.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: FOUND LOWER SHELF OF PREPARATION TABLE WITH CHIPPING PAINT.

FOOD (ICE) DISPENSING UTENSILS, WASH CLOTHS PROPERLY STORED - Comments: FOUND WASHCLOTHS NOT STORED PROPERLY.

CLEAN MULTI-USE UTENSILS AND SINGLE SERVICE ARTICLES PROPERLY STORED: NO REUSE OF SINGLE SERVICE ARTICLES - Comments: FOUND FOOD CONTAINERS NOT STORED PROPERLY. MUST STORE INVERTED.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: FOUND FLOORS IN POOR REPAIR AT PACKAGING AREAS.MUST SEAL OR REPAIR.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: FOUND CEILING IN POOR REPAIR /NOT SMOOTH AND EASY TO CLEAN AT PACKAGING AND LOADING AREAS.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: FOUND TOOLS STORED IMPROPERLY ON SHELVING UNITS BY 2 COMPARTMENT SINK.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: Rusted metal shelvings in one of the walk in freezer in the rear storage area. Must remove rust and maintain. Door of the chest freezer not in good repair. Interior panel broken. Must repair or replace.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: Must sanitize and clean in detail all the cart inside the walk in cooler with food crumbs and maintain. Must clean,sanitize and organize all the bottom shelve of the prep tables and lid and exterior part of all bulk containers and maintain.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: Must clean the floor in all walk in cooler and walk in freezer and maintain. Must remove all the milk crate being used as a pallet inside the storage room, walk in cooler and walk in freezer. Provide regular pallet or shelvings to store stocks.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: Must clean in detail the walls behind the prep tables and maintain. Must clean the vents inside the washroom in the packaging area,(with dust accumulated). Must scrape peeling paint along the window rim and walls inside the washroom in the prep area and repaint.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: CAULKING WORN OUT AROUND THE EXPOSED HAND SINK IN THE PREP AREA, AROUND THE WASHBOWL SINK IN THE PREP AREA WASHROOM AND FINISHING AREA WASHROOM. INSTRUCTED TO RE CAULK AND MAINTAIN.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: PEELING PAINT ON THE WALLS BY THE EXPOSED HAND SINK, BY THE STORAGE AREA,ON THE WALLS BY THE SOAP HOLDER INSIDE THE PREP AREA WASHROOM AND WALLS AND CEILING INSIDE THE FINISHING AREA WASHROOM. MUST REMOVE PEELING PAINT,REPAINT AND MAINTAIN.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: BURNED OUT LIGHT BULB ABOVE THE PREP AREA. MUST REPLACE AND MAINTAIN.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: SEAL HOLE IN WALL AROUND TUBING IN VENTILATION ROOM INSIDE WEST BUILDING.

TOILET ROOM DOORS SELF CLOSING: DRESSING ROOMS WITH LOCKERS PROVIDED: COMPLETE SEPARATION FROM LIVING/SLEEPING QUARTERS - Comments: PROVIDE SELF CLOSING DEVICE FOR WASHROOM IN WEST SIDE OF BUILDING NEXT TO WALK IN COOLERS.

REFRIGERATION AND METAL STEM THERMOMETERS PROVIDED AND CONSPICUOUS - Comments: PROVIDE THERMOMETERS FOR 3 DOOR COOLER ON EAST SIDE OF BUILDING.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: All food and non-food contact equipment and utensils shall be smooth, easily cleanable, and durable, and shall be in good repair. REMOVE DUCT TAPE ON REACH IN CHEST FREEZER IN REAR. REPAIR OR REPLACE AS NEEDED.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All food and non-food contact surfaces of equipment and all food storage utensils shall be thoroughly cleaned and sanitized daily. REMOVE ACCUMULATED FOOD DEBRIS FROM DOUGH MAKER NEXT TO PREP AREA DOOR.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned. REPAIR LEAK FROM CEILING OUTSIDE REAR DOOR.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: Shielding to protect against broken glass falling into food shall be provided for all artificial lighting sources in preparation, service, and display facilities. PROVIDE MISSING OR BROKEN LIGHT SHIELDS ABOVE WALK IN FREEZER IN GARAGE, INSIDE COOLING UNITS IN FRONT DISPLAY AREA AND THROUGHOUT PREMISES AS NEEDED.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: Ventilation: All plumbing fixtures, such as toilets, sinks, washbasins, etc., must be adequately trapped, vented, and re-vented and properly connected to the sewer in accordance with the plumbing chapter of the Municipal Code of Chicago and the Rules and Regulations of the Board of Health. REPAIR LEAK UNDER 2 COMPARTMENT SINK.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: All parts of the food establishment and all parts of the property used in connection with the operation of the establishment shall be kept neat and clean and should not produce any offensive odors. TIRES, PAPER, CLUTTER ON WEST SIDE OF BUILDING MUST BE REMOVED AND REAR AREA CLEANED.