CHILI MAC'S 5-WAY CHILI

FOOD IN ORIGINAL CONTAINER, PROPERLY LABELED: CUSTOMER ADVISORY POSTED AS NEEDED - Comments: ALL BULK FOOD CONTAINERS MUST BE LABELED. ALL PREPARED FOODS IN COOLER MUST BE LABELED AND DATED.

CLEAN MULTI-USE UTENSILS AND SINGLE SERVICE ARTICLES PROPERLY STORED: NO REUSE OF SINGLE SERVICE ARTICLES - Comments: DIRTY TABLE TOP CAN OPENER ENCRUSTED WITH FOOD DEBRIS. MUST CLEAN AFTER EACH USE.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: MUST NOT USE TIN FOIL OR TORN PLASTIC AS LINER FOR SHELVING THROUGHOUT FRONT PREP SHELVING. WOODEN CABINET/SHELVING ENCASING THE PIZZA PREP EXPOSED HAND SINK DAMAGED BY WATER, CHIPPING AND PEELING CAULKING UNABLE TO CLEAN. MUST REPLACE AND MAKE SMOOTH AND CLEANABLE. LID OF BOX FREEZER IN PIZZA PREP AREA BROKEN WITH EXPOSED INSULATION. MUST REPLACE.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: EXTERIOR COOKS LINE EQUIPMENT BETWEEN DEEP FRYER AND STEAM TABLE WITH EXCESSIVE GREASE BUILD UP. MUST REMOVE. INTERIOR ICE MACHINE MUST CLEAN.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: FLOOR TILES UNDER COOKS LINE EQUIPMENT CRACKED AND IN POOR REPAIR. MUST REPAIR/REPLACE AND MAKE FLOORS SMOOTH AND CLEANABLE. FLOORS THROUGHOUT PIZZA PREP MUST CLEAN, REMOVE FLOUR, DIRT.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: HOLE IN WALL ACROSS FROM DISH WASH AREA. MUST SEAL. WATER DAMAGED CEILING TILES IN PIZZA PREP AREA. MUST REPLACE.

TOILET ROOM DOORS SELF CLOSING: DRESSING ROOMS WITH LOCKERS PROVIDED: COMPLETE SEPARATION FROM LIVING/SLEEPING QUARTERS - Comments: WOMANS WASHROOM SELF-CLOSING DOOR DEVICE BROKEN. MUST REPAIR OR REPLACE.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: FOLLOWING PLUMBING REPAIRS MUST BE MADE: BROKEN SPRAY ARM AT DISH MACHINE HANGING DOWN ONTO DIRTY DISH BASIN. BROKEN EXPOSED HAND SINK IN BAR/PREP AREA. MUST PROVIDE HOT/COLD RUNNING WATER. INSTRUCTED TO USE ADDITIONAL EXPOSED HAND SINK NEXT TO FRONT PREP. NO HOT/COLD RUNNING WATER AT FRONT TAYLOR MACHINE NOT IN USE AT THIS TIME USED FOR FROZEN MARGARITAS. MUST PROVIDE AND MACHINE TAGGED HELD FOR INSPECTION. MUST NOT USE UNTIL WATER PROVIDED AND C.D.P.H. CONTACTED FOR INSPECTION AND TAG REMOVAL.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: UNUSED ICE MACHINE ON PREMISES MUST BE REMOVED.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: DETAIL CLEAN THE DOOR SEALS WITH ENCRUSTED FLOUR BUILDUP INSIDE OF THE PIZZA PREP COOLER, INTERIOR OF THE PIZZA OVEN, INTERIOR OF COKE COOLER, EXTERIOR OF THE GREASE TRAP, INTERIOR AND EXTERIOR OF THE MICROWAVE, VENTILATION HOOD IN THE FRONT PREP AREA, GRILL.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: The floors shall be constructed per code, be smooth and easily cleaned, and be kept clean and in good repair. REMOVE THE CARPETING BEHIND THE BAR AREA. DETAIL CLEAN THE FLOOR THROUGHOUT.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned. DETAIL CLEAN THE WALLS OF THE PIZZA PREP AREA AND DISHWASH AREA.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: Shielding to protect against broken glass falling into food shall be provided for all artificial lighting sources in preparation, service, and display facilities. PROVIDE A LIGHT SHIELD ABOVE THE GRILL AREA.

FOOD PROTECTED DURING STORAGE, PREPARATION, DISPLAY, SERVICE AND TRANSPORTATION - Comments: All food should be properly protected from contamination during storage, preparation, display, service, and transportation. FOOD (ICE) NOT PROTECTED DURING STORAGE INSIDE OF THE ICE MACHINE. OBSERVED MOLD GROWTH ON INTERIOR SURFACES OF THE ICE MACHINE. UNIT TAGGED BY CDPH. INSTRUCTED MANAGEMENT TO TURN OFF MACHINE, REMOVE ICE AND HAVE THE INTERIOR OF THE UNIT CLEANED AND SANITIZED. SERIOUS VIOLATION 7-38-005A.

PREVIOUS MINOR VIOLATION(S) CORRECTED 7-42-090 - Comments: A separate and distinct offense shall be deemed to have been committed for each Minor violation that is not corrected upon re-inspection by the health authority. PREVIOUS MINOR VIOLATIONS FROM REPORT #164138 ON 8/20/09 NOT CORRECTED: 32/01-REPLACE BROKEN INSIDE LINER OF TOP DOOR OF CHEST FREEZER, INSULATION EXPOSED. 34/01-REPLACE BROKEN AND MISSING FLOOR TILES ESPECIALLY UNDER EQUIPMENT AND PIZZA PREP AREA. SERIOUS VIOLATION 7-42-090.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All food and non-food contact surfaces of equipment and all food storage utensils shall be thoroughly cleaned and sanitized daily. DETAIL CLEAN THE DOOR SEALS WITH ENCRUSTED FLOUR BUILDUP INSIDE OF THE PIZZA PREP COOLER, INTERIOR OF THE PIZZA OVEN AND THE VENTILATION FILTERS ATTCHED TO THE PIZZA OVEN, INTERIOR OF COKE COOLER, EXTERIOR OF THE GREASE TRAP, EXTERIOR OF THE DISHWASHER, INTERIOR AND EXTERIOR OF THE MICROWAVE, VENTILATION HOOD IN THE FRONT PREP AREA.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: The floors shall be constructed per code, be smooth and easily cleaned, and be kept clean and in good repair. REMOVE THE CARPETING BEHIND THE BAR AREA. DETAIL CLEAN THE FLOOR THROUGHOUT.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned. DETAIL CLEAN THE WALLS OF THE PIZZA PREP AREA AND DISHWASH AREA. REPLACE THE MISSING WALL TILES IN THE DISHWASH AREA.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: Shielding to protect against broken glass falling into food shall be provided for all artificial lighting sources in preparation, service, and display facilities. PROVIDE A LIGHT SHIELD ABOVE THE GRILL AREA.