PINEDA'S BAKERY

SOURCE SOUND CONDITION, NO SPOILAGE, FOODS PROPERLY LABELED, SHELLFISH TAGS IN PLACE - Comments: OBSERVED MISBRANDED AND UNWHOLESOME INDIVIUALLY PACKAGED CONTAINERS OF TRES LECHE CAKE DISPLAYED AND BEING OFFERED FOR SALE IN DISPLAY CASE ON SALES FLOOR. OBSERVED PRE PRINTED DATE OF 01/17/18 WITH SELL BY DATE OF 1/15/18, HAS BEEN COVERED WITH BLACK MARKER AND RE LABELED WITH HANDWRITTEN DATE OF 1/17/18 , SELL BY 1/24/18 NOW ON PACKAGES, WHICH IS PAST EXPIRATION DATE. MISBRANDING OF SUCH IS PROHIBITED. ALL PRODUCT DISCARDED AND DENATURED AT THS TIME. 10LBS $25 VALUE. VIOLATION 7-38-005B CRITICAL.

POTENTIALLY HAZARDOUS FOOD MEETS TEMPERATURE REQUIREMENT DURING STORAGE, PREPARATION DISPLAY AND SERVICE - Comments: POTENTIALLY HAZARDOUS FOODS AT IMPROPER TEMPERATURE DURING STORAGE. 1 DOZEN EGGS AT IMPROPER TEMPERATURE OF 58.1F IN WALK IN COOLER. EGGS DISCARDED AND DENATURED AT THIS TIME. APPRX 2LBS $3 VALUE. INSTD TO MAINTAIN PROPER TEMPERATURE OF 40F OR BELOW AT ALL TIMES. VIOLATION 7-38-005A CRITICAL.

FOOD IN ORIGINAL CONTAINER, PROPERLY LABELED: CUSTOMER ADVISORY POSTED AS NEEDED - Comments: WHOLE TRES LECHES CAKE IN DISPLAY CASE WITHOUT LABEL. INSTD TO PROPERLY LABEL. INDIVIDIAL PACKAGED CAKES LABELED WITHOUT INGREDIENTS IN ENGLISH. INSTD TO CORRECT AND MAINTAIN

REFRIGERATION AND METAL STEM THERMOMETERS PROVIDED AND CONSPICUOUS - Comments: METAL STEM THERMOMETER MISSING FOR FOOD HANDLERS. PROVIDE SAME.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: REPAIR THE SINK STOPPER LEVERS AT THE 3 COMPARTMENT SINK SO THAT THEY CAN ALL HOLD WATER IN THE BASINS.

PREVIOUS MINOR VIOLATION(S) CORRECTED 7-42-090 - Comments: PREVIOUS MINOR VIOLATIONS FROM 12/15/14 REPORT 1512993 NOT CORRECTED: 32 OBSERVED SPLASH GUARDS NEEDED ON EACH SIDE OF EXPOSED HANDSINK. INSTALL AND MAINTAIN SPLASHGUARDS.

ADEQUATE NUMBER, CONVENIENT, ACCESSIBLE, DESIGNED, AND MAINTAINED - Comments: EXPOSED HANDSINK WITH EXCESSIVE LEAK AT PIPE UNDERNEATH. INSTD TO REPAIR PIPE FREE OF ANY LEAKS. CITATION ISSUED 7-38-030 CRITICAL.

NO EVIDENCE OF RODENT OR INSECT OUTER OPENINGS PROTECTED/RODENT PROOFED, A WRITTEN LOG SHALL BE MAINTAINED AVAILABLE TO THE INSPECTORS - Comments: OVER 50 LIVE SMALL FLIES FLYING IN REAR BY STORAGE ROOM AND IN TOILET ROOM. INSTD TO ELIMINATE ALL FLIES, CLEAN AND SANITIZE ALL AFFECTED AREAS. RECOMMEND TO CONTACT PEST CONTROL FOR SERVICE. CITATION ISSUED 7-38-020 SERIOUS.

* CERTIFIED FOOD MANAGER ON SITE WHEN POTENTIALLY HAZARDOUS FOODS ARE PREPARED AND SERVED - Comments: NO CITY OF CHICAGO CERTIFIED MANAGER ON DUTY WHILE HANDLING POTENTIALLY HAZARDOUS FOODS (EGGS, MILK). INSTD TO HAVE ON DUTY AT ALL TIMES. CITATION ISSUED 7-38-012 SERIOUS.

PREVIOUS MINOR VIOLATION(S) CORRECTED 7-42-090 - Comments: PREVIOUS MINOR VIOLATIONS FROM 12/15/14 REPORT 1512993 NOT CORRECTED: 30 ALL PREPACKAGED FOOD MUST BE LABELED. LABEL ALL FOOD THAT IS PACKAGED WITH DATE, INGREDIENTS, NAME OF ESTABLISHMENT. (GELATINS, RICE PUDDING, PASTRIES, ETC). 32 OBSERVED SPLASH GUARDS NEEDED ON EACH SIDE OF EXPOSED HANDSINK. INSTALL AND MAINTAIN SPLASHGUARDS. 34 OBSERVED FLOORS UNCLEAN IN THE FOLLOWING AREAS: FLOOR OF WALK IN COOLER, FLOOR OF WALK IN FREEZER AND FLOOR UNDER AND HEHIND ALL SHELVING AND LARGE EQUIPMENT, ALONG WALLS AND IN CORNERS. CLEAN ANS MAINTAIN FLOORS. 35 OBSERVED CEILING VENT IN BAKERY ABOVE FOOD WITH HEAVY DUST ACCUMULATION. CLEAN AND MAINTAIN CEILING VENT. 35 OBSERVED WALL OF SERVICE AREA OF BAKERY WITH PEELING PAINT. RESTORE WALL TO A SMOOTH EASILY CLEANABLE SURFACE AND MAINTAIN. 36 OBSERVED INADEQUATE LIGHTING WITHIN WALK IN COOLER. REPLACE OR REPAIR LIGHT AND MAINTAIN. NO CHEMICAL TEST KITS FOR 3-COMPARTMENT SINK. PROVIDE SAME. CITATION ISSUED 7-42-090 SERIOUS.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: CEILING ABOVE PROOFERS, OVENS NOT CLEAN, STAINED FROM EXHAUST. INSTD TO CLEAN CEILING, REMOVE STAINS, AND MAINTAIN.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: LIGHT OUT IN WALK-IN FREEZER. REPLACE SAME.

TOILET ROOM DOORS SELF CLOSING: DRESSING ROOMS WITH LOCKERS PROVIDED: COMPLETE SEPARATION FROM LIVING/SLEEPING QUARTERS - Comments: TOILET ROOM DOOR NOT SELF-CLOSING. INSTD TO CORRECT SAME.

FOOD (ICE) DISPENSING UTENSILS, WASH CLOTHS PROPERLY STORED - Comments: WIPING CLOTHS IMPROPERLY STORED. INSTD TO STORE PROPERLY IN SANITIZING SOLUTIONS.

FOOD IN ORIGINAL CONTAINER, PROPERLY LABELED: CUSTOMER ADVISORY POSTED AS NEEDED - Comments: ALL PREPACKAGED FOOD MUST BE LABELED. LABEL ALL FOOD THAT IS PACKAGED WITH DATE, INGREDIENTS, NAME OF ESTABLISHMENT.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: OBSERVED SPLASH GUARDS NEEDED ON EACH SIDE OF EXPOSED HANDSINK. INSTALL AND MAINTAIN SPLASHGUARDS.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: OBSERVED FLOORS UNCLEAN IN THE FOLLOWING AREAS: FLOOR OF WALK IN COOLER, FLOOR OF WALK IN FREEZER AND FLOOR UNDER AND HEHIND ALL SHELVING AND LARGE EQUIPMENT, ALONG WALLS AND IN CORNERS. CLEAN ANS MAINTAIN FLOORS.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: OBSERVED CEILING VENT IN BAKERY ABOVE FOOD WITH HEAVY DUST ACCUMULATION. CLEAN AND MAINTAIN CEILING VENT.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: OBSERVED WALL OF SERVICE AREA OF BAKERY WITH PEELING PAINT. RESTORE WALL TO A SMOOTH EASILY CLEANABLE SURFACE AND MAINTAIN.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: OBSERVED INADEQUATE LIGHTING WITHIN WALK IN COOLER. REPLACE OR REPAIR LIGHT AND MAINTAIN.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: DOOR HANDLES OF OVENS, COOLERS, AND ALL DISPENSING UTENSILS FOR DRY STORAGE NOT CLEAN. INSTD TO CLEAN SAME AND MAINTAIN.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: WALLS IN PREP AREA NOT CLEAN, SPLASHED WITH FOOD DEBRIS. INSTD TO CLEAN AND MAINTAIN.

TOILET ROOM DOORS SELF CLOSING: DRESSING ROOMS WITH LOCKERS PROVIDED: COMPLETE SEPARATION FROM LIVING/SLEEPING QUARTERS - Comments: EMPLOYEES PERSONAL BELONINGS IMPROPERLY STORED. INSTD TO STORE IN DESIGNATED AREA.

FOOD IN ORIGINAL CONTAINER, PROPERLY LABELED: CUSTOMER ADVISORY POSTED AS NEEDED - Comments: THE BULK FOOD CONTAINERS IN THE BAKERY NOT LABELED. INSTRUCTED TO LABEL THEM.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: THE GASKETS AROUND THE REACHIN FREEZER DOORS ARE IN POOR REPAIR THEY ARE RIPPED AND TORN. INSTRUCTED TO REPAIR OR REPAIR THEM.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: MUST CLEAN THE MIXERS, PREP TABLES, TRAVEL CARTS AND THE REACHIN COOLERS HAVE FOOD DEBRIS ALL OVER THEM.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: CLEAN THE FLOORS THROUGHOUT PREMISES ALONG THE WALLS AND IN THE CORNERS AND UNDER THE HEAVY EQUIPMENT HAS DUST AND FOOD DEBRIS ALL OVER THEM.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: SEAL ALL THE HOLES IN THE WALLS THROUGHOUT PREMISES SO NO INSECT OR RODENT HARBORAGE. CLEAN ALL THE CEILING VENTS THROUGHOUT PREMISES THICK WITH DUST AND DIRT ON THEM.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: CLEAN THE TWO VENTS IN THE TOILET ROOM THEY HAVE DUST BUILDUP ON THEM.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: CLUTTER IN THE PREP AREA. INSTRUCTED TO CLEAN AND ORGNIZE SO NO INSECT OR RODENT HARBORAGE.

WATER SOURCE: SAFE, HOT & COLD UNDER CITY PRESSURE - Comments: All food establishments shall be provided with an adequate supply of hot and cold water under pressure properly connected to the city water supply.OBSERVED NO HOT RUNNING WATER ON SITE AT HAND SINKS IN PREP AREA & TOILET ROOM,3-COMPARTMENT SINK AT THIS TIME OF INSPECTION,WHILE FOOD IS BEING PREPARED & HANDLED.HOT RUNNING WATER WAS RESTORED 1 HOUR LATER.MUST PROVIDE HOT RUNNING WATER AT ALL TIMES.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: All food and non-food contact equipment and utensils shall be smooth, easily cleanable, and durable, and shall be in good repair.MUST REPAIR OR REPLACE WORN DOOR GASKETS ON 3- DOOR GLASS COOLER,LOOSE CEILING VENT COVER.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All food and non-food contact surfaces of equipment and all food storage utensils shall be thoroughly cleaned and sanitized daily.MUST DETAIL CLEAN FOOD DEBRI FROM FLOOR MIXERS,ROLLING CARTS,PREP TABLES,PRESSOR,REACH IN COOLERS,SHELVING UNITS,STORAGE CABINETS,FOOD STORAGE CONTAINERS,WINDOW SILLS.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: The floors shall be constructed per code, be smooth and easily cleaned, and be kept clean and in good repair.MUST DETAIL CLEAN FOOD DEBRI FROM FLOOR ALONG WALL BASES THROUGHOUT PREMISES.MUST REPLACE DAMAGED FLOOR TILES WHERE NEEDED.MUST CLEAN ALL FLOOR DRAINS.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned.MUST CLEAN FOOD DEBRI FROM WALLS THROUGHOUT.MUST SCRAPE & PAINT PEELING PAINT ON WALL ON SALES FLOOR.FINISH PAINTING CEILING IN REAR PREP AREA.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: All rooms in which food or drink is prepared, or in which utensils are washed, shall be lighted so that a minimum of 50-foot candles of light is available on all work surfaces.REPLACE BURNT OUT LIGHT BULBS WHERE NEEDED.

TOILET ROOM DOORS SELF CLOSING: DRESSING ROOMS WITH LOCKERS PROVIDED: COMPLETE SEPARATION FROM LIVING/SLEEPING QUARTERS - Comments: Toilet rooms shall be completely enclosed and shall be vented to the outside air or mechanically ventilated.MUST REPAIR OR REPLACE DAMAGED SELF CLOSING DEVICE ON TOILET ROOM DOOR.