HOT ROD GRILL

* CERTIFIED FOOD MANAGER ON SITE WHEN POTENTIALLY HAZARDOUS FOODS ARE PREPARED AND SERVED - Comments: AT 230PM DURING INSPECTION FOUND NO CERTIFIED CITY OF CHICAGO FOOD SERVICE MANAGER ON PREMISES WHILE POTENTIALLY HAZARDOUS FOODS WERE BEING PREPARED AND HANDLED. MUST ALWAYS HAVE A CERTIFIED CITY OF CHICAGO FOOD SERVICE MANAGER ON PREMISES AT ALL TIMES WHEN POTENTIALLY HAZARDOUS FOODS ARE BEING HANDLED, PREPARED AND COOKED. SERIOUS CITATION ISSUED.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: MUST DETAIL CLEAN INTERIOR OF BOTH DEEP FRYERS. TO REMOVE GREASE BUILD-UP.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: MUST DECLUTTER/BETTER ORGANIZE MOP SINK ROOM AREA SO AS TO HAVE ALL ITEMS 6 INCHES OFF THE FLOOR AT ALL TIMES.

HAND WASHING FACILITIES: WITH SOAP AND SANITARY HAND DRYING DEVICES, CONVENIENT AND ACCESSIBLE TO FOOD PREP AREA - Comments: FOUND REAR EXPOSED HAND SINK BY THE THREE COMPARTMENT SINKS/ REAR PREP AREA WITHOUT RUNNING HOT WATER,HOT WATER VALVE WAS TURNED OFF UNDER THE SINK. OBSERVED EMPLOYEE WASHING HANDS AT THREE COMPARTMENT SINK. EMPLOYEE TURNED ON HOT WATER VALVE AFTER MY REQUEST.BUSINESS OPERATING AT PRESENT TIME.INFORMATION GIVEN ON HAND WASHING. CRITICAL VIOLATION:7-38-030

NO EVIDENCE OF RODENT OR INSECT OUTER OPENINGS PROTECTED/RODENT PROOFED, A WRITTEN LOG SHALL BE MAINTAINED AVAILABLE TO THE INSPECTORS - Comments: OUTER OPENINGS NOT PROTECTED,FOUND BOTH FRONT AND REAR DOOR WIDE OPENED,SCREEN DOOR FOR THE REAR DOOR MESH IS BROKEN,BOTTOM PART. INSTRUCTED TO KEEP DOOR CLOSED,NEED TO REPAIR SCREEN DOOR IF REAR DOOR IS KEPT OPENED. SERIOUS VIOLATION: 7-38-020

OUTSIDE GARBAGE WASTE GREASE AND STORAGE AREA; CLEAN, RODENT PROOF, ALL CONTAINERS COVERED - Comments: OUTSIDE WASTE GREASE OIL CONTAINER NOT MAINTAINED. EXTERIOR OF THE CONTAINER HAS A BUILD-UP OF GREASE, OIL IS SPLASHED ON GARAGE DOOR. RAT DROPPINGS WERE OBSERVED OUTSIDE AREA IN FRONT EXIT DOOR AND BETWEEN THE BROWN FENCES WHICH IS STORED ON FLOOR AND LEANING AGAINST THE BUILDING,SOUTH AREA.OBSERVED A HOLE UNDER THE STEP OF REAR DOOR AND CEMENT FLOOR. LIDS OF GARBAGE CONTAINER ARE BROKEN AND CHEWED BY ANIMALS,INSTRUCTED TO REPLACE LIDS,CLEAN WASTE OIL CONTAINER AND GARAGE DOOR,TO MINIMIZE RODENTS AND INSECTS ACTIVITIES, REMOVE RAT DROPPINGS FROM MENTIONED AREA. SERIOUS VIOLATION: 7-38-020

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: FOUND TWO REGULAR IRONS ON PREMISES WHICH IS USED TO FLATTEN HAMBURGERS,INSTRUCTED TO REMOVE AND PROVIDE A FOOD GRADE UTENSILS.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: NO SPLASH GUARD PROVIDED BETWEEN THE FRONT EXPOSED HAND SINK ,STEAM TABLE AND PREP TABLE.INSTRUCTED TO PROVIDE SURFACE MUST BE SMOOTH,CLEANABLE AND NON-ABSORBENT MATERIAL

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: INTERIOR OF MICROWAVE TOP PART HAS A BUILD-UP OF ENCRUSTED FOOD,INSTRUCTED TO CLEAN AND MAINTAIN. THE SPLASH GUARD WHICH IS INSTALLED BETWEEN THE REAR EXPOSED HAND SINK AND THREE COMPARTMENT SINK HAS A BUILD-UP OD DUST INSTRUCTED TO CLEAN AND MAINTAIN.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: NO STOPPERS PROVIDED AT THREE COMPARTMENT SINK,INSTRUCTED TO PROVIDE.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: Remains to be corrected by 5/1/12.

NO EVIDENCE OF RODENT OR INSECT OUTER OPENINGS PROTECTED/RODENT PROOFED, A WRITTEN LOG SHALL BE MAINTAINED AVAILABLE TO THE INSPECTORS - Comments: FRONT ENTRANCE DOOR WITH 1/4 OF AN INCH GAP AT THE BOTTOM OF THE DOOR. TWO EXIT DOORS WITH GAP ON THE LFT SIDE OF THE DOOR. INSTRUCTED TO RODENT/INSECTS PROOF THE DOORS. CITATION ISSUED SERIOUS.

* CERTIFIED FOOD MANAGER ON SITE WHEN POTENTIALLY HAZARDOUS FOODS ARE PREPARED AND SERVED - Comments: A certified food service manager must be present in all establishments at which potentially hazardous food is prepared or served. NO CERTIFIED FOOD MANAGER ON SITE WHILE PREPARING AND SERVING POTENTIALLY HAZARDOUS FOODS SUCH AS HOT DOG, HAMBURGER, GRILLED CHICKEN GYROS,CHILI ETC AT THE TIME OF INSPECTION. CITATION ISSUED SERIOUS.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: MISSING THREE DRAIN STOPPER FOR THE 3 COMPARTMENT SINK. MUST PROVIDE.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: MISSING COVING ON THE BIG DINING AREA, MUST INSTALL COVING 4" THROUGHOUT.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: STAINED CEILING TILES INSIDE THE WASHROOM. MUST REPLACE. CEILING VENTILATION COVER, WITH DUST BUILT UP. MUST CLEAN AND MAINTAIN.

APPROPRIATE METHOD OF HANDLING OF FOOD (ICE) HAIR RESTRAINTS AND CLEAN APPAREL WORN - Comments: EMPLOYEE PREPARING AND COOKING FOODS MUST WEAR A HAIR RESTRAINT.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: SEAL GAP IN FLOOR AND ALONG WALL BEHIND 3 COMPARTMENT SINK.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: REPAIR SLOW DRAINING 3 COMPARTMENT SINK IN REAR.

FOOD IN ORIGINAL CONTAINER, PROPERLY LABELED: CUSTOMER ADVISORY POSTED AS NEEDED - Comments: All food not stored in the original container shall be stored in properly labeled containers. LABEL POTATO AND ALL DRY STORAGE BINS AS WELL AS STORED FOODS IN REFIGERATION UNITS.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: All food and non-food contact equipment and utensils shall be smooth, easily cleanable, and durable, and shall be in good repair. PROVIDE COVERS FOR ALL GARBARGE CONTAINERS THROUGHOUT PREMISES. REMOVE CONTACT PAPER FROM CABINET NEXT TO FRONT DISPLAY COOLER.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All food and non-food contact surfaces of equipment and all food storage utensils shall be thoroughly cleaned and sanitized daily. DETAIL CLEAN INSIDE AND OUTSIDE OF ALL EQUIPMENT THROUGHOUT PREMISES.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: The floors shall be constructed per code, be smooth and easily cleaned, and be kept clean and in good repair. REMOVE CHEMICALS, TOOLS ETC AND CLEAN FLOOR OF MOP SINK ROOM. STORE ITEMS AT LEAST 6" OFF OF FLOOR. DETAIL CLEAN FLOORS THROUGHOUT PREMISES, ALONG WALLS AND BEHIND EQUIPMENT. REMOVE WATER ON FLOOR IN BASEMENT NEXT TO HOT WATER TANK. DETERMINE SOURCE, REPAIR AND MAINTAIN DRY FLOOR. SEAL GAP IN FLOOR AND ALONG WALL BEHIND 3 COMPARTMENT SINK. MAKE IT SMOOTH AND EASILY CLEANABLE.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: Ventilation: All plumbing fixtures, such as toilets, sinks, washbasins, etc., must be adequately trapped, vented, and re-vented and properly connected to the sewer in accordance with the plumbing chapter of the Municipal Code of Chicago and the Rules and Regulations of the Board of Health. REPAIR SLOW DRAINING 3 COMPARTMENT SINK IN REAR.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: All parts of the food establishment and all parts of the property used in connection with the operation of the establishment shall be kept neat and clean and should not produce any offensive odors. REMOVE ALL CONSTRUCTION CLUTTER IN REAR AREA OF DINING ROOM.