ZULLO'S

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: No drain board provided to the 3-comp sink, Instructed to install.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: CLEAN THE MEAT SLICER, DRY FOOD STORAGE CONTAINERS, GRILL, DEEP FRYER, PLASTIC STORAGE SHELF NEXT TO THE 3-COMPARTMENT SINK, AND THE PREP TABLE BENEATH THE GRILL.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: OBSERVED NO COVERED WASTE RECEPTACLE PROVIDED IN THE EMPLOYEE WASHROOM. MANAGEMENT INSTRUCTED TO PROVIDE.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: CLEAN THE FLOOR OF THE FOOD PREP AREA BENEATH THE COOKING EQUIPMENT, IN THE CORNER NEAR THE CONVECTION OVENS AND THE SMALL WALK-IN COOLER.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: OBSERVED A FOOD HANDLING EMPLOYEE PREPARING FOOD WITHOUT A FOOD HANDLER CERTIFICATE. MANAGEMENT INSTRUCTED THAT ALL EMPLOYEES MUST SHOW PROOF OF TRAINING.

THERMOMETERS PROVIDED & ACCURATE - Comments: OBSERVED BOTH METAL STEM THERMOMETERS ON SITE AT TIME OF INSPECTION DO NOT TURN ON. INSTRUCTED TO REPAIR OR REPLACE AND MAINTAIN FUNCTIONAL METAL STEM THERMOMETERS ON SITE AT ALL TIMES. PRIORITY FOUNDATION VIOLATION 7-38-005. CITATION ISSUED.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: OBSERVED APPROXIMATELY 40 RODENT DROPPINGS UNDER REAR STAIRS, IN REAR HALLWAY AND IN BASEMENT NEAR WATER HEATER AND REAR STORAGE AREA. INSTRUCTED TO REMOVE DROPPPINGS, RECEIVE ADDITIONAL PEST CONTROL SERVICE AND MAINTAIN FACILITY FREE OF PEST ACTIVITY. PRIORITY FOUNDATION VIOLATION 7-38-020(A). CITATION ISSUED.

PERSONAL CLEANLINESS - Comments: OBSERVED BOTH EMPLOYEES WORKING WITHOUT HAIR RESTRAINTS. INSTRUCTED FOOD HANDLERS MUST WEAR HAIR RESTRAINTS.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED BUILD UP OF GREASE AND GRIME ON FILTERS OF HOOD OVER COOK LINE. INSTRUCTED TO CLEAN AND MAINTAIN IN GOOD CONDITION.

ALLERGEN TRAINING AS REQUIRED - Comments: OBSERVED 1 OF 2 CERTIFIED MANAGERS ON DUTY WITHOUT ALLERGEN TRAINING. INSTRUCTED ALL EMPLOYEES HOLDING CITY OF CHICAGO FOOD SERVICE MANAGER CERTIFICATES MUST COMPLETE ALLERGEN TRAINING AND MAINTAIN RECORDS THEREOF.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: NO HANDWASHING SIGNS AT HANDWASHING SINKS IN PREP AREAS. MUST PROVIDE.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED CRACKED LIGHT SJIELD INSIDE WALK IN COOLER. MUST REPLACE.

PROPER EATING, TASTING, DRINKING, OR TOBACCO USE - Comments: OBSERVED EMPLOYEES DRINKS STORED IN PREP AREA WITHOUT LID. INSTRUCTED TO PROVIDE LID ON CUP AND DESIGNATE ARE FOR DRINKING. MUST MAINTAIN.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: OBSERVED HAND-SINK LOCATED IN PREP AREA BLOCKED BY ROLLING STORAGE SHELVING UNIT WHERE LARGE POTS & NOT IN USE KITCHENWARE ARE STORED. UNABLE TO ACCESS HAND-SINK TO WASH HANDS DURING TIME OF INSPECTION.MUST REMOVE AND PROVIDE ACCESS TO HAND-SINK AT ALL TIMES. PRIORITY FOUNDATION VIOLATION. 7-38-030 (c). CITATION ISSUED.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED FOIL LINERS ON ALL SHELVING UNITS THROUGHOUT PREP AREA. INSTRUCTED TO REMOVE AND PROVIDE SMOOTH AND EASILY CLEANABLE SURFACES. MUST MAINTAIN.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: OBSERVED DOOR ON TOILET ROOM NOT SELF CLOSING. INSTRUCTED TO PROVIDE AND MAINTAIN.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED BLACK CRATES USED FOR ELEVATION IN BASEMENT STORAGE. INSTRUCTED TO REMOVE ALL UNNECESSARY ITEMS AND ELEVATE STORED ITEMS AT LEAST 6 INCHES ABOVE THE FLOOR.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED DISH WASHER NOT SANITIZING DISHES PROPERLY AT 3 COMP SINK IN THE KITCHEN/PREP AREA. TEST STRIPS RECORDED 0 PPM READING FROM CHEMICAL SANITIZER. INSTRUCTED THAT CHEMICAL SANITIZER, QUATERNARY AMMONIUM SHOULD BE BETWEEN 150-400 PPM. PRIORITY FOUNDATION VIOLATION 7-38-005 CITATION ISSUED.

GARBAGE & REFUSE PROPERLY DISPOSED; FACILITIES MAINTAINED - Comments: OBSERVED TRASH OVERFLOWING AND TRASH LIDS UNABLE TO CLOSE ON THE OUTSIDE RECEPTACLES OF THE FACILITY. INSTRUCTED THAT OUTSIDE RECEPTACLE LIDS MUST BE TIGHT IN ORDER TO PREVENT PEST HARBORAGE. PRIORITY FOUNDATION VIOLATION 7-38-020(b) CITATION ISSUED.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: OBSERVED LARGE BULK CONTAINERS OF SUGAR, FLOUR, OATES, BROWN SUGAR WITH NO COMMON NAME. INSTRUCTED THAT WHEN OUT OF THE ORIGINAL CONTAINER, FOOD MUST BE IDENTIFIED WITH COMMON NAME.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: MUST DETAIL CLEAN THE EXTERIOR SIDES OF COOKING EQUIPMENT TO REMOVE DEBRIS AND GREASE.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED LARGE HOLE IN THE CEILING ABOVE THE HAND SINK AGAINST THE SOUTH WALL. INSTRUCTED TO REPAIR AND MAINTAIN.

FOOD-CONTACT SURFACES: CLEANED & SANITIZED - Comments: OBSERVED THE INSIDE OF THE ICE MACHINE IN THE BASEMENT WITH A BUILD-UP OF DIRT AND GRIME. INSTRUCTED TO CLEAN, SANITIZE, AND MAINTAIN.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: OBSERVED LARGE BULK CONTAINERS OF SUGAR, FLOUR, OATES, BROWN SUGAR WITH NO COMMON NAME. INSTRUCTED THAT WHEN OUT OF THE ORIGINAL CONTAINER, FOOD MUST BE IDENTIFIED WITH COMMON NAME.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: OBSERVED APPROX 60 SMALL FLIES HOOVERING IN THE AREA BETWEEN THE KITCHEN AND THE ENTRANCE TO THE BASEMENT. INSTRUCTED TO CALL OUT PEST CONTROL, CLEAN AND SANITIZE ALL AFFECTED AREAS. PRIORITY FOUNDATION VIOLATION 7-38-020(a) CITATION ISSUED.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: MUST DETAIL CLEAN THE EXTERIOR SIDES OF COOKING EQUIPMENT TO REMOVE DEBRIS AND GREASE.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: FLOORS NEED DETAIL CLEANING AROUND ALL COOKING EQUIPMENT AND STORAGE SHELVING, ALSO INSIDE THE WALK IN COOLER TO REMOVE SPILL AND DEBRIS.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED LARGE HOLE IN THE CEILING ABOVE THE HAND SINK AGAINST THE SOUTH WALL. INSTRUCTED TO REPAIR AND MAINTAIN.