AMERICAN CRAFT

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: Above violation still remaining(Observed broken floor around east side compactor/dumpster, instructed to repair floor, instructed to service drainage system).

SANITIZING RINSE FOR EQUIPMENT AND UTENSILS: CLEAN, PROPER TEMPERATURE, CONCENTRATION, EXPOSURE TIME - Comments: Observed employee washing dishes at 3 compartment sink without sanitizer. technician was called in and turn on the sanitizing solution valve. Citation issued 7-38-030 critical violation.

ADEQUATE NUMBER, CONVENIENT, ACCESSIBLE, DESIGNED, AND MAINTAINED - Comments: Observed hand sink in the omelet food preparation area without cold water-hot water at 123.6F. sink was repaired during the inspection Citation issued 7-38-030 critical violation.

OUTSIDE GARBAGE WASTE GREASE AND STORAGE AREA; CLEAN, RODENT PROOF, ALL CONTAINERS COVERED - Comments: Observed waste water and accumulated garbage under and around dumpsters, instructed to clean all affected areas. Citation issued 7-38-020, serious violation.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: Clean utensils stored in the hand sink cabinet, under the waste waste water pipe. Must remove.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: Observed broken floor around east side compactor/dumpster, instructed to repair floor, also waste water is not draining into the floor drain under west side dumpster, instructed to service drainage system.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: MUST REPAIR LEAK AT HOT WATER FAUCET HANDLE AT THE 3-COMP SINK IN FRONT OF THE LARGE DISH MACHINE. MUST REPAIR LEAK UNDER THE PIPE AT THE 2-COMP SINK IN THE REAR PREP STATION AREA. MUST ADJUST THE TEMPERATURE AT THE HAND SINK IN THE REAR PREP STATION AREA SO AS TO BE 85F AT ALL TIMES FOR A MINIMUM OF 15 SECS.

FOOD HANDLER REQUIREMENTS MET - Comments: MUST PROVIDE ALL FOOD STAFF WITH THEIR ILLINOIS FOOD HANDLER'S CERTIFICATE AT ALL TIMES. MUST PROVIDE FOR THE NEXT ROUTINE INSPECTION.

NO EVIDENCE OF RODENT OR INSECT OUTER OPENINGS PROTECTED/RODENT PROOFED, A WRITTEN LOG SHALL BE MAINTAINED AVAILABLE TO THE INSPECTORS - Comments: INADEQUATE INSECTS CONTROL, FOUND 6 LIVE COCKROACHES BEHIND PREP TABLE IN MAIN KITCHEN, INSTRUCTED TO ELIMINATE INSECTS ACTIVITY IN ALL AFFECTED AREAS, PEST CONTROL SERVICE RECOMMENDED. SERIOUS CITATION ISSUED. 7-38-020

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: DUSTY FAN COVERS AT KITCHEN WALLS, INSTRUCTED TO CLEAN AND MAINTAIN.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: INADEQUATE SNEEZE GUARD AT PASTERY AND CUT FRUIT SELF SERVICE STATIONS, INSTRUCTED MGR TO INSTALL AN EFFECTIVE ONE THAT WILL PREVENT CUSTOMERS CONTAMINATION.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: CARDBOARD LIKE MATERIAL THATS ABSORBANT COVERING SHELVES FOR CLEAN UTENSILS, INSTRUCTED TO REMOVE AND USE NON-ABSORBANT SMOOTH SURFACE.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: GASKETS FOR PREP COOLER NOT CELAN. FOOD DEBRIS NOTED, INSTRUCTED TO CLEAN AND MAINTAIN.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: FLOOR NOT CLEAN ALONG WALL BASE AND CORNERS, INSTRUCTED TO CLEAN AND MAINTAIN.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: MISSING CEILING PANELS IN KITCHEN PREP AREA, INSTRUCTED TO REPLACE.

REFRIGERATION AND METAL STEM THERMOMETERS PROVIDED AND CONSPICUOUS - Comments: REFRIGERATION THERMOMETER FOR PACKAGED SANDWICHES OPEN COOLER KEPT IN THE REAR. INSTRUCTED MGR TO KEEP IN THE WARMEST PART OF COOLER AND EASY TO MONITOR.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: MOPS AND BROOMS STORED TOO CLOSE TO CLEAN UTENSILS SHELVES, INSTRUCTED TO KEPP AWAY.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: IN THE DISH MACHINE AREA MUST DETAIL CLEAN AND SANITIZE LARGE FANS WITH EXCESSIVE DUST BUILD UP.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: MUST CLEAN FLOORS AT REAR MAIN KITCHEN AREA AS WELL AS BACK PREP AREA AT FLOOR CORNERS TO REMOVE FOOD DEBRIS AND CRUMBS.

FOOD IN ORIGINAL CONTAINER, PROPERLY LABELED: CUSTOMER ADVISORY POSTED AS NEEDED - Comments: MUST LABEL ALL BULK INGREDIENT CONTAINERS IN THE PREP AREA.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: MUST REPLACE CUTTING BOARDS WITH DEEP/DARK GROOVES IN PREP AREA.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: MUST REPLACE WORN RUBBER GASKET ON TALL REACH IN COOLER BY THE STEAM TABLE ON THE HOT LINE.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: MUST REMOVE EXCESS ICE AND CLEAN THE INTERIOR OF THE ICE CREAM FREEZER IN THE PREP AREA.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: MUST SEAL THE HOLE IN THE WALL IN THE REAR ROOM SERVICE PREP AREA ABOVE THE DOOR LEADING TO THE STAIR WAY.

NO EVIDENCE OF RODENT OR INSECT OUTER OPENINGS PROTECTED/RODENT PROOFED, A WRITTEN LOG SHALL BE MAINTAINED AVAILABLE TO THE INSPECTORS - Comments: All necessary control measures shall be used to effectively minimize or eliminate the presence of rodents, roaches, and other vermin and insects on the premises of all food establishments, in food-transporting vehicles, and in vending machines. FOUND ABOUT 15 LIVE COCKROACHES CRAWLING UNDER PREP TABLES AND ON KITCHEN WALLS, ALSO OVER 30 LIVE FRUIT FLIES NOTED ON KITCHEN WALLS, INSTRUCTED MGR TO ELIMINATE INSECTS ACTIVITY IN ALL AFFECTED AREAS, PEST CONTROL SERVICE RECOMMENDED.

PREVIOUS MINOR VIOLATION(S) CORRECTED 7-42-090 - Comments: A separate and distinct offense shall be deemed to have been committed for each Minor violation that is not corrected upon re-inspection by the health authority. PREVIOUS MINOR VIOLATION NOT CORRECTED FROM REPORT #197500 DATED ON 06-21-10. FOR VIOLATION # 32( MUST INSTALL A DIPPER WELL FOR ICE CREAM SCOOP, MUST SEAL CRACKS ON WALK-IN COOLER CEILING THATS CAUSING CONDENSATION AND DRIPPINGS.) INSTRUCTED TO CORRECT VIOLATIONS WITHIN GIVEN TIME FRAME

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: All food and non-food contact equipment and utensils shall be smooth, easily cleanable, and durable, and shall be in good repair. MUST INSTALL A DIPPER WELL FOR ICE CREAM SCOOPS, CRACKS NOTED ON WALK-IN COOLERS CEILING CAUSING CONDENSATION AND DRIPPINGS INSTRUCTED TO SEAL CRACKS AND INSTALL A DIPPER WELL.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: The floors shall be constructed per code, be smooth and easily cleaned, and be kept clean and in good repair. FOOD SPILLS ON DEBRIS NOTED ON KITCHEN FLOORS UNDER PREP TABLE, INSTRUCTED TO CLEAN AND MAINTAIN.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned. HOLES NOTED IN WALK-IN COOLERS AND KITCHEN WALLS, INSTRUCTED TO SEAL.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: All food and non-food contact equipment and utensils shall be smooth, easily cleanable, and durable, and shall be in good repair. MUST INSTALL A DIPPER WELL FOR ICE CREAM STATION.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All food and non-food contact surfaces of equipment and all food storage utensils shall be thoroughly cleaned and sanitized daily. SHELVES IN PREP AREA NOT CLEAN, ICE BUILD UP INSIDE WALK-IN FREEZER, INSTRUCTED TO REMOVE AND MAINTAIN.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned. WALLS AND CEILING ARE I POOR REPAIR, PEELING PAINT NOTED ON WALL BEHIND DEEP FRYER, ALSO PEELING PAINT NOTED ON DROP CEILING PANELS HOLDERS, INSTRUCTED TO REMOVE AND MAINTAIN.