NEW WAYNE'S BARBECUE & CAJUN INC

POTENTIALLY HAZARDOUS FOOD MEETS TEMPERATURE REQUIREMENT DURING STORAGE, PREPARATION DISPLAY AND SERVICE - Comments: NOTED THE FOLLOWING POTENTIALLY HAZARDOUS FOOD ITEMS IN PREP AREA IN PANS AT IMPROPER INTERNAL TEMPERATURES RANGING FROM 55.6F-69.2F DEGREES; PRE-COOKED ORANGE CHICKEN,GRILLED CHICKEN AND PORK RIBS, APPROX. WT. 7LBS, VALUE $8.40. MANAGER VOLUNTARILY DENATURED AND EXPOSED OF FOOD ITEMS. MUST MAINTAIN PROPER FOOD TEMPERATURES. CRITICAL VIOLATION, 7-38-005(A).

FOOD PROTECTED DURING STORAGE, PREPARATION, DISPLAY, SERVICE AND TRANSPORTATION - Comments: NOTED PAN OF PRE-COOKED ORANGE CHICKEN IN PAN ON FLOOR IN DRY FOOD STORAGE AREA NOT PROTECTED FROM THE ELEMENTS, INSTRUCTED TO ELEVATE AND COVER. MUST PROTECT FOOD AT ALL TIMES. SERIOUS VIOLATION, 7-38-005(A).

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: CLEAN THE FOLLOWING: EXTERIORS OF ALL FOOD STORAGE CONTAINERS, ALL STORAGE SHELVES & RACKS THROUGHOUT, INTERIOR CABINETS & EXTERIORS OF DEEP FRYERS. ALSO CLEAN INTERIOR OF FRONT 2-DOOR FREEZER AT BOTTOM. MUST CLEAN.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: CLEAN EXCESSIVE DEBRIS ON FLOORS UNDER SINKS,AROUND HOT WATER TANK,MOP SINK AND THROUGHTOUT PREP AREA. MUST CLEAN.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All food and non-food contact surfaces of equipment and all food storage utensils shall be thoroughly cleaned and sanitized daily.GREASE TRAP,FOOD CONTACT EQUIPMENT NOT CLEAN/DEBRIS.MUST CLEAN/MAINTAIN.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: The floors shall be constructed per code, be smooth and easily cleaned, and be kept clean and in good repair.FLOOR DRAIN AND FOORS IN STORAGE AREA NOT CLEAN.MUST CLEAN.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: The flow of air discharged from kitchen fans shall always be through a duct to a point above the roofline.WASHROOM VENT DUSTY.MUST CLEAN.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All food and non-food contact surfaces of equipment and all food storage utensils shall be thoroughly cleaned and sanitized daily.DETAIL CLEAN DEBRIS FROM EXTERIOR OF GREASE TRAP,NOT CLEAN.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: The floors shall be constructed per code, be smooth and easily cleaned, and be kept clean and in good repair. CLEAN EXCESSIVE DEBRIS ON FLOORS UNDER SINKS,AROUND HOT WATER TANK,MOP SINK.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned.SEAL GAP/OPENING ALONG BASEBOARD IN EMPLOYEE WASHROOM TO PREVENT HIDING AREA FOR PEST.

FOOD IN ORIGINAL CONTAINER, PROPERLY LABELED: CUSTOMER ADVISORY POSTED AS NEEDED - Comments: All food not stored in the original container shall be stored in properly labeled containers. LABEL/Date food not in original container,chicken,etc. also cover foods/wrap.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: All food and non-food contact equipment and utensils shall be smooth, easily cleanable, and durable, and shall be in good repair.MUST INSTALL PAPER TOWEL DEVICE AT HAND SINK IN PREP AREA.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: The floors shall be constructed per code, be smooth and easily cleaned, and be kept clean and in good repair. MUST REMOVE STORAGE OFF FLOORS ON SHELVING IN STORAGE ROOM 1.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: The flow of air discharged from kitchen fans shall always be through a duct to a point above the roofline. Ventilation: All plumbing fixtures, such as toilets, sinks, washbasins, etc., must be adequately trapped, vented, and re-vented and properly connected to the sewer in accordance with the plumbing chapter of the Municipal Code of Chicago and the Rules and Regulations of the Board of Health. MUST ADJUST OVEN COMPLETELY UNDER VENTILATION HOOD. OR REMOVE OVEN.

SANITIZING RINSE FOR EQUIPMENT AND UTENSILS: CLEAN, PROPER TEMPERATURE, CONCENTRATION, EXPOSURE TIME - Comments: UNABLE TO PROBERLY SANTIZE MULTI-USE UTENSILS. THE DIVIDER BETWEEN THE 2ND AND 3RD SINK NOT SEALED NOTED RINSE WATER AND SANTIZING WATER MIXING. SEAL DEVIDER BETWEEN THE SINKS TO SEAL EACH COMPARTMENT.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: REPLACE ALL WORN/STAINED WHITE CHOPPING BOARDS.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: DETAIL CLEAN BASEBOARDS THROUGHOUT, HEAVY SOIL BUILD-UP. CLEAN FLOORS BEHIND ALL HEAVY EQUIPTMENT.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: SEAL ALL HOLES, CRACKS CREVICES ON WALLS/CEILINGS THROUGHOUT, PREVENTING ANY INSECT ENTRANCE/HORBAGE. MAKING WALLS LIGHT IN COLOR AND EASY CLEANABLE.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: DETAIL CLEAN ALL LIGHT SHIELDS THROUGHOUT.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: SECURE EXPOSED HAND SINK TO WALL.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: All food and non-food contact equipment and utensils shall be smooth, easily cleanable, and durable, and shall be in good repair. REPLACE OR PAINT RUSTY SHELVES & RACKS THROUGHOUT

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All food and non-food contact surfaces of equipment and all food storage utensils shall be thoroughly cleaned and sanitized daily. CLEAN THE FOLLOWING: EXTERIORS OF ALL FOOD STORAGE CONTAINERS, ALL STORAGE SHELVES & RACKS THROUGHOUT, INTERIOR CABINETS & EXTERIORS OF DEEP FRYERS.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: and ceilings shall be in good repair and easily cleaned. REMOVE ALL ALUMINUM FOIL FROM WALLS IN KITCHEN & PROPERLY SEAL EXPOSED HAND SINK TO WALL IN KITCHEN AREA.

OUTSIDE GARBAGE WASTE GREASE AND STORAGE AREA; CLEAN, RODENT PROOF, ALL CONTAINERS COVERED - Comments: The area outside of the establishment used for the storage of garbage shall be clean at all times and shall not constitute a nuisance. GREASE ON THE EXTERIOR OF DUMPSTER IN GARBAGE CORAL, LIDS NOT KEPT CLOSED, TRASH & DEBRIS ALSO NOTED ON GROUND- CITATION ISSUED-SERIOUS

PREVIOUS MINOR VIOLATION(S) CORRECTED 7-42-090 - Comments: A separate and distinct offense shall be deemed to have been committed for each Minor violation that is not corrected upon re-inspection by the health authority. GREASE BUILD-UP STILL NOTED ON THE EXHAUST HOOD ABOVE GRILL AND DEEP FRYER. CUTTING BOARDS STILL NOT CLEAN. FLOORS UNDERNEATH TABLES & UNDERNEATH ALL HEAVY EQUIPMENT STILL NOT CLEAN (LOT'S OF DEBRIS & GREASE NOTED). LIGHT SHIELDS STILL NOT CLEAN IN THE EXHAUST HOOD, STILL NEED TO PROVIDE WORKING LIGHT BULB- CITATION ISSUED-SERIOUS FOR NON-COMPLIANCE WITH PREVIOUS MINOR VIOLATIONS

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: All food and non-food contact equipment and utensils shall be smooth, easily cleanable, and durable, and shall be in good repair. REPLACE OR PAINT RUSTY SHELVES & RACKS THROUGHOUT

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All food and non-food contact surfaces of equipment and all food storage utensils shall be thoroughly cleaned and sanitized daily. CLEAN THE FOLLOWING: EXTERIORS OF ALL FOOD STORAGE CONTAINERS, ALL STORAGE SHELVES & RACKS THROUGHOUT, INTERIOR CABINETS & EXTERIORS OF DEEP FRYERS.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned. REMOVE ALL ALUMINUM FOIL FROM WALLS IN KITCHEN & PROPERLY SEAL EXPOSED HAND SINK TO WALL IN KITCHEN AREA.