TOKYO MARINA

SANITIZING RINSE FOR EQUIPMENT AND UTENSILS: CLEAN, PROPER TEMPERATURE, CONCENTRATION, EXPOSURE TIME - Comments: LOW TEMP DISH MACHINE NOT DISPENSING SANITIZER,0PPM. UNIT IN USE FOR LUNCH TIME: DISHES,MULTI USE UTENSILS AND CUPS. TAGGED UNIT" HELD FOR INSPECTION" DO NOT USE. INSTRUCTED TO USE THREE COMPARTMENT SINKS FOR:WASH RINS AND SANITIZE, 100PPM. CRITICAL VIOLATION:7-38-030

ADEQUATE NUMBER, CONVENIENT, ACCESSIBLE, DESIGNED, AND MAINTAINED - Comments: EXPOSED HAND SINK AT FRONT SUSHI AREA REMOVED,INSTRUCTED TO RE-INSTALL SAID SINK UNDER THE CITY PLUMBING CODE,MUST PROVIDE HAND DRYING DEVICE/PAPER TOWELS AND SOAP AT EXPOSED HAND SINK.INSTRUCTED TO USE EXPOSED HAND SINK IN THE KITCHEN BEHIND SUSHI AREA. CRITICAL VIOLATION:7-38-030

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: INTERIOR LID OF CHEST FREEZER IS BROKEN AND RUSTY, A WIRE IS WRAPPED AROUND THE LID TO HOLD INTERIOR LINER,ALSO RUBBER GASKET IS BROKEN.INSTRUCTED TO REPLACE SAID LID. UNIT IS LOCATED IN BASEMENT BY THE OLD ICE MACHINE. MEAT SLICE IS LOCATED AT REAR STORAGE AREA,INSTRUCTED TO REMOVE/RELOCATE OR INSTALL AN EXPOSED HAND SINK. REAR STORAGE IS USED FOR MULTIPLE PURPOSE. CLEAN POTS ARE HANGING ON WALLS,MEAT SLICER CLEANING MOPS,SNOW BLOWER AND ETC.IF THE STORAGE IS USED TO STORE FOOD AND FOOD PRODUCTS MUST REMOVE NON-FOOD ITEMS AND VICE VERSA. BROWN CUTTING BOARDS IN POOR REPAIR(DEEP CUTS AND SURFACE IS PEELING,INSTRUCTED TO REPLACE

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: GREASE ON OVEN DOORS INSTRUCTED TO CLEAN AND MAINTAIN.REMOVE DUST THROUGHOUT THE PIPE IN KITCHEN. PINK MINERAL BUILD-UP INSIDE THE ICE MACHINE ,INSTRUCTED TO CLEAN AND SANITIZE UNIT

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: MISSING WALL TILES INSIDE THE STAFF WASHROOM,INSTRUCTED TO REPLACE. HOLE ON CEILING TILE ABOVE THE DISH MACHINE INSTRUCTED TO SEAL WITH A SMOOTH CLEANABLE AND NON-ABSORBENT MATERIAL. CEILING WALL MISSING ABOVE THE CHEST FREEZER IN BASEMENT AREA,INSTRUCTED TO PROVIDE IT WITH A SMOOTH CLEANABLE AND NON-ABSORBENT MATERIAL

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: MOP SINK THAT WAS INSTALLED IN BASEMENT IS REMOVED, INSTRUCTED TO RE-INSTALL SAID SINK AND FOLLOW CITY PLUMBING CODE.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: OBSERVED CHEST FREEZERS UNDER THE WASTE WATER PIPE,IN BASEMENT AREA,INSTRUCTED TO RELOCATE THEM AWAY FROM WASTE WATER PIPE.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: OBSERVED ACCUMULATED DUST BUILD UP ON FAN COVER ABOVE 3-COMPARTMENT SINK, FOOD DEBRIS INSIDE UNUSED STAND UP REACH IN COOLER AT REAR PREP AND FOOD BUILD UP INSIDE REACH IN COOLERS DOOR GASKETS. MUST CLEAN AND MAINTAIN UNCLEAN EQUIPMENT.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: OBSERVED FOOD STAINS/FOOD BUILD UP ON WALLS IN REAR KITCHEN AND GAP IN WALL BETWEEN PIPE (BEHIND WOK). MUST CLEAN ALL WALLS AND SEAL GAP IN WALL/PIPE AT SAID AREA.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: REAR PREP EXPOSED HANDWASH BOWL WATER LEAKING BY HOT/COLD WATER HANDLES. MUST REPAIR SINK.

REFRIGERATION AND METAL STEM THERMOMETERS PROVIDED AND CONSPICUOUS - Comments: NO METAL STEM THEROMETER FOR FOOD HANDLERS. INSTRUCTED MANAGER TO PROVIDE AND CALIBRATE METAL STEM THERMOMETER FOR FOOD HANDLERS.

NO EVIDENCE OF RODENT OR INSECT OUTER OPENINGS PROTECTED/RODENT PROOFED, A WRITTEN LOG SHALL BE MAINTAINED AVAILABLE TO THE INSPECTORS - Comments: All necessary control measures shall be used to effectively minimize or eliminate the presence of rodents, roaches, and other vermin and insects on the premises of all food establishments, in food-transporting vehicles, and in vending machines. OBSERVED OVER 20 RAT DROPPINGS ON BASEMENT FLOOR ALONG SOUTH WALL OF 5060 N. CLARK BASEMENT SIDE. MUST REMOVE ALL RAT DROPPINGS/ELIMINATE PEST BY DATE OF REINSPECTION (02/17/12).

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: All food and non-food contact equipment and utensils shall be smooth, easily cleanable, and durable, and shall be in good repair. OBSERVED DARK PITS ON SURFACE OF CUTTING BOARD ON TOP OF REACH IN PREP COOLER BY COOKLINE. MUST REPLACE/REPAIR DAMAGED CUTTING BOARD.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All food and non-food contact surfaces of equipment and all food storage utensils shall be thoroughly cleaned and sanitized daily. OBSERVED ACCUMULATED FOOD DEBRIS ON LOWER SIDE OF PREP AREA TABLE TOPS AND FOOD DEBRIS ON EXTERIOR OF ALL COOLERS AND SINKS IN PREP AREA. MUST CLEAN AND MAINTAIN ALL UNCLEAN EQUIPMENT.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: The floors shall be constructed per code, be smooth and easily cleaned, and be kept clean and in good repair. INSTRUCTED MANAGER TO DETAIL CLEAN FLOOR THROUGHOUT BASEMENT AND UNDER AND AROUND ALL EQUIPMENT THROUGHOUT PREP AND DISHWASH AREA.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: All parts of the food establishment and all parts of the property used in connection with the operation of the establishment shall be kept neat and clean and should not produce any offensive odors. OBSERVED CLUTTER ALONG SOUTH WALL ON BASEMENT FLOOR AT 5060 N. CLARK SIDE. MUST REMOVE ALL CLUTTER OR ELEVATE 6" OFF FLOOR.

FOOD IN ORIGINAL CONTAINER, PROPERLY LABELED: CUSTOMER ADVISORY POSTED AS NEEDED - Comments: All food not stored in the original container shall be stored in properly labeled containers.//VIOLATION REMAINING SEE REPORT #525244.

CLEAN MULTI-USE UTENSILS AND SINGLE SERVICE ARTICLES PROPERLY STORED: NO REUSE OF SINGLE SERVICE ARTICLES - Comments: Containers and utensils shall be inverted, covered, or otherwise protected from contamination until used. All single-service drinking straws and containers shall be discarded immediately after use.//VIOLATION REMAINING SEE REPORT #525244.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: All food and non-food contact equipment and utensils shall be smooth, easily cleanable, and durable, and shall be in good repair.//VIOLATION REMAINING SEE REPORT #525244.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All food and non-food contact surfaces of equipment and all food storage utensils shall be thoroughly cleaned and sanitized daily.//VIOLATION REMAINING SEE REPORT #525244.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: The floors shall be constructed per code, be smooth and easily cleaned, and be kept clean and in good repair.//VIOLATION REMAINING SEE REPORT #525244.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned.//VIOLATION REMAINING SEE REPORT #525244.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: Shielding to protect against broken glass falling into food shall be provided for all artificial lighting sources in preparation, service, and display facilities.//VIOLATION REMAINING SEE REPORT #525244.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: The flow of air discharged from kitchen fans shall always be through a duct to a point above the roofline.//VIOLATION REMAINING SEE REPORT #525244.

NO EVIDENCE OF RODENT OR INSECT OUTER OPENINGS PROTECTED/RODENT PROOFED, A WRITTEN LOG SHALL BE MAINTAINED AVAILABLE TO THE INSPECTORS - Comments: All necessary control measures shall be used to effectively minimize or eliminate the presence of rodents, roaches, and other vermin and insects on the premises of all food establishments, in food-transporting vehicles, and in vending machines.//REAR DOOR LEADING TO ALLEY MEASURED AT 1/2 " AT BOTTOM OF DOOR/DOOR ON SIDE IN REAR LEADING TO STREET (CARMEN AVE) DOOR 1/4"-1/2" AT BOTTOM.

FOOD IN ORIGINAL CONTAINER, PROPERLY LABELED: CUSTOMER ADVISORY POSTED AS NEEDED - Comments: All food not stored in the original container shall be stored in properly labeled containers.//NEED NAMES DATES ON FOOD ITEMS IN STORAGE.

CLEAN MULTI-USE UTENSILS AND SINGLE SERVICE ARTICLES PROPERLY STORED: NO REUSE OF SINGLE SERVICE ARTICLES - Comments: Containers and utensils shall be inverted, covered, or otherwise protected from contamination until used. All single-service drinking straws and containers shall be discarded immediately after use.//NEED TO PROPERLY STORE ALL CLEAN MULTI-USE UTENSILS IN PREP AREA

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: All food and non-food contact equipment and utensils shall be smooth, easily cleanable, and durable, and shall be in good repair.//MUST REPLACE ALL STAIN & BADLY PITTED CUTTING BOARDS IN PREP AREA/NEED LIDES ON ALL GARBAGE CANS IN PREP AREA WHEN NOT IN USE/NEED SPLASH GUARD ON FRONT EXPOSED HAND BOWL & PREP COUNTER/NEED STOPPERS FOR ALL SINKS IN PREP AREA/MUST REMOVE RUSTY GREASE TRAP TOP UNDER 3COMP. SINK,SHELVES IN REACH IN COOLERS IN KITCHEN AREA BOTTOM OFDRY STORAGE SHELVE IN REAR NEXT TO REAR DOOR OR PAINT/NEED LIDES FOR ALL FOOD ITEMS IN STORAGE

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All utensils shall be thoroughly cleaned and sanitized after each usage.//SOME SHELVES IN COOLERS DRY STORAGE INTERIOR & EXTERIOR OF EQUIPMENT NEED CLEANING.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: The floors shall be constructed per code, be smooth and easily cleaned, and be kept clean and in good repair.//FLOOR UNDER & AROUND STOCK NEED CLEANING/MUST STORE ALL STOCK 6" OFF FLOOR WHEN IN STORAGE./MUST REMOVE MILK & SODA CRATIES OFF PREMISES USED FOR SHELVES TO STORE FOOD.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: Use dustless cleaning methods. The walls and ceilings shall be in good repair and easily cleaned.//MUST REPLACE ALL STAIN & IN POOR REPAIR CEILING TILE IN REAR AREA,HOLE IN CEILING TILE./DETAIL CLEAN OR REPAINT WALLS IN REAR PREP AREA/MUST PAINT RAW WOOD IN CEILING IN EMPLOYEE RESTROOM.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: All rooms in which food or drink is prepared, or in which utensils are washed, shall be lighted so that a minimum of 50-foot candles of light is available on all work surfaces.//MUST CLEAN LIGHT SHELDES OVER FOOD PREP AREA IN REAR.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: Ventilation: All plumbing fixtures, such as toilets, sinks, washbasins, etc., must be adequately trapped, vented, and re-vented and properly connected to the sewer in accordance with the plumbing chapter of the Municipal Code of Chicago and the Rules and Regulations of the Board of Health.//MUST INSTALL DIPPER WELL FOR HAND PACKED ICE CREAM IN PREP AREA COOLER/BASE OF FAUCET LEAKING WATER ON 3COMP. & 2COMP SINK IN PREP AREA/MUST REATTACH WASTE DRAIN LINE TO MOP SINK IN BASEMENT

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: All food and non-food contact equipment and utensils shall be smooth, easily cleanable, and durable, and shall be in good repair. DEFROST AND MAINTAIN THE INTERIOR OF THE STANDUP FREEZER IN THE REAR STORAGE AREA.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All food and non-food contact surfaces of equipment and all food storage utensils shall be thoroughly cleaned and sanitized daily. DETAIL CLEAN THE FOLLOWING EQUIPMENT: WIRE STORAGE RACKS NEAR THE 3 COMPARTMENT SINK, LIGHT SHIELDS IN THE PREP AREA, THE PREP COOLER AND MICROWAVE.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned. DETAIL CLEAN THE WALLS AND CEILING OF THE ROOM NEAR THE BACK EXIT DOOR. REPAINT THE DOOR TO THE KITCHEN. SEAL ALL OPENINGS IN THE WALL ABOVE THE 3 COMPARTMENT SINK.

FOOD PROTECTED DURING STORAGE, PREPARATION, DISPLAY, SERVICE AND TRANSPORTATION - Comments: All food should be properly protected from contamination during storage, preparation, display, service, and transportation. FOOD (ICE) NOT PROTECTED DURING STORAGE INSIDE OF THE ICE MACHINE. OBSERVED MOLD GROWTH ON INTERIOR CONTACT SURFACES OF THE ICE MACHINE. UNIT TAGGED HELD FOR INSPECTION. MANAGEMENT INSTRUCTED TO REMOVE THE ICE FROM THE MACHINE AND HAVE THE INTERIOR OF THE UNIT CLEANED AND SANITIZED. FAX REINSPECTION LETTER TO (312) 746-4240 AFTER THE UNIT HAS BEEN CLEANED AND IS READY FOR REINSPECTION. SERIOUS VIOLATION 7-38-005A.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: All food and non-food contact equipment and utensils shall be smooth, easily cleanable, and durable, and shall be in good repair. DEFROST AND MAINTAIN THE INTERIOR OF THE STANDUP FREEZER IN THE REAR STORAGE AREA.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All food and non-food contact surfaces of equipment and all food storage utensils shall be thoroughly cleaned and sanitized daily. DETAIL CLEAN THE FOLLOWING EQUIPMENT: WIRE STORAGE RACKS NEAR THE 3 COMPARTMENT SINK, LIGHT SHIELDS IN THE PREP AREA, THE PREP COOLER AND MICROWAVE.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned. DETAIL CLEAN THE WALLS AND CEILING OF THE ROOM NEAR THE BACK EXIT DOOR. REPAINT THE DOOR TO THE KITCHEN. SEAL ALL OPENINGS IN THE WALL ABOVE THE 3 COMPARTMENT SINK.